MATERIAL SAFETY DATA SHEET
Product Name: Conducting Silver Paint
Catalog Number:
60805
DOT Hazard Class: Class 3 (Product packaged in Excepted
Quantity)
MSDS Updated: 8/12/02
Distributed By: Ladd Research
83 Holly Court
Williston, VT
05495
(802) 658-4961
HAZARDOUS
COMPONENTS
CAS Number
Percent Exposure Limits
1-Methoxy-2-Propanol Acetate
108-65-6 10-30% Not Available
Butyl Acetate 123-86-4
10-30% 150
ppm (OSHA PEL)
Dibutyl Phthalate 84-74-2
1-5% 5 mg/m³ (OSHA PEL)
Silver (Metallic) 7440-22-4
30-60% 0.1
mg/m³ (ACGIH TWA)
Fatty Acid Derivative
NA 0.1-1% Not
Available
Acrylic Resin (Proprietary) NA 10-30% Not Available
Proprietary Ingredient(s) NA
<0.1% Not Available
PHYSICAL AND
CHEMICAL DATA
Form: Liquid
Appearance: Grey
Odor: Mild fruity
Solubility in
Water: Slight
FIRE AND
EXPLOSION HAZARD DATA
Flashpoint: 72EF
(Tag Closed Cup)
Fire and
Explosion Hazards: Keep away
from sparks and open flames. Do not
smoke in area with open product. The
solvent vapors are heavier than air and may travel along the floor to a source
of ignition and flash back. Consider
the need for spark proof tools. If the
product may be heated above it’s flash point during processing, remove sources
of ignition such as open sparks, flames or static discharge to prevent vapor
ignition.
Extinguishing
Media: Water spray, dry
chemical or carbon dioxide
Special Fire
Fighting Information: Wear
full protective clothing and a full face piece, positive pressure,
self-contained breathing apparatus.
Decontaminate contaminated clothing and equipment with soap and water.
HEALTH HAZARD
DATA
Primary Route(s)
of Entry: Inhalation, skin
Eye: Irritation
Skin: Irritation
Inhalation: Irritation of mucosal surfaces
EMERGENCY AND
FIRST AID
Skin: Immediately wash skin with soap and plenty
water.
Eye: Immediately flush eyes with plenty water for
at least 15 minutes.
Inhalation: Remove patient to fresh air immediately. If not breathing, give artificial
respiration. If breathing is difficult,
give oxygen. Call a physician.
Ingestion: DO NOT induce vomiting. Immediately give two glasses of water or
activated charcoal slurry. Never give
anything by mouth to an unconscious person.
Call a physician.
REACTIVITY
DATA
Stability: Stable
Incompatibility: Avoid contact with oxidizing agents, acids,
potassium tert-butoxide.
Hazardous
Decomposition Products: Oxides
of carbon, water, and oxides of nitrogen
Hazardous
Polymerization: The product
does not normally polymerize significantly.
SPILL,
DISPOSAL AND STORAGE INFORMATION
Spill: Absorb on rags, sand or other absorbent
material.
Disposal: Product may be refined to recover precious
metal content. Consult local, state or
federal regulations for allowable disposal methods.
Storage: Store product below 90EF to ensure product viscosity stability. Do not store product in areas where vapors
may contact sources of heat, sparks or open flame.
PROTECTIVE
EQUIPMENT AND CONTROL MEASURES
Ventilation: Local ventilation should be used to keep
exposures below applicable limits.
Respiratory: Respirator with organic vapor cartridges
provide adequate protection.
Gloves: Butyl rubber gloves recommended.
SECTION 313
SUPPLIER NOTIFICATION
The following
ingredients are subject to the reporting requirements of section 313 of Title
III of the Superfund Amendment and Reauthorization Act of 1986 and of 40CFR372:
Dibutyl Phthalate [84-74-2]
Silver [7440-22-4]
{ { { { { { { { { { { { { { { { { { { { { { { { { { { { { { { { { { { { { { { {
The information presented is believed to be correct and is the most accurate information available to us at this time. However, Ladd Research makes no warranty, express or implied, and assumes no liability for this information and the product described herein.